• 联系人:小马师傅
  • 电话:18560041881
  • 地址:济南市北园大街86号
新闻中心当前位置:首页-新闻中心
    来源:http://www.jndmzp.com/   时间:
    2mm环氧济南自流平地坪涂装操作步骤
    来源:http://www.jndmzp.com   时间:2014-1-2 10:32:00

    :地坪漆施工前打磨清洁地面:施工标准:地面无油渍、无水痕、沥青、无水泥疙瘩、无乳胶漆、无水泥浮灰等异物,2m 靠尺不大于3mm;
    First: polished cleaned before construction of the ground floor paint: construction standards: the ground without oily be soiled, no water marks, asphalt, cement bumps, emulsioni paint, cement float ash foreign body, such as 2 m by foot is not more than 3 mm;
    第二:涂底漆:用量0.1~0.15kg/m2(甲组分),用普通滚筒涂刷;施工标准:济南自流平表面无粉尘及松散砂粒,底漆干后,地面微亮方可进行下一道工序; 施工要求:(a)在离墙、柱、设备较近的地方涂油漆时应慢速推拉滚筒,防止滚筒速度过快而将油漆飞溅到墙壁或设备上;
    Second: primer: dosage of 0.1 ~ 0.15 kg/m2 (first division), using ordinary roller coating; Jinan self-leveling construction standards: no dust and loose sand surface, primer is dry, the ground under the dim light can procedure; Construction requirements: (a) in closer from the walls, pillars, equipment where the paint should be slow when push-pull roller, prevent roller too fast and will paint splash on the walls or equipment;
    (b)对于吸油量较大的地方补涂底漆,直到符合底漆要求;(或刮环氧底漆一遍,配比环氧高固含砂浆漆:固化剂=4:1,油漆用量0.15 ~0.2 kg/m2,刮刀刮涂;施工标准:表面平整,无颗粒、无浮砂、无明显砂眼);
    (b) for touch-up primer oil absorption is larger, until the conform to the requirements of the primer; (or epoxy primer again, the proportion of high build epoxy mortar paint: curing agent = 4:1, paint dosage is 0.15 ~ 0.2 kg/m2, scraper blade coating; construction standards: surface level off, without particles, sand, no obvious sand holes);
    第三:刮环氧中砂浆一遍配比环氧高固含砂浆漆:固化剂:中砂=4:1:10-15,油漆用量0.35~0.4kg/m2,用刮刀刮涂;施工标准:表面平整,无刀痕、无浮砂、无明显砂眼;
    Third: blowing ratio of epoxy mortar again in the high solid content slurry epoxy paint, curing agent, medium sand = 4:1:10-15, paint dosage is 0.35 ~ 0.4 kg/m2, with a scraper blade coating; Construction standards: surface smooth, no scar, no sand, no obvious sand holes;
    第四:刮环氧细砂浆一遍,配比环氧高固含砂浆漆:固化剂:细砂=4:1:9-10,油漆用量0.22~0.25kg/m2,用刮刀刮涂;施工标准:表面平整,无刀痕、无浮砂、无明显砂眼;
    Fourth: fine epoxy mortar again, the ratio of high build epoxy mortar paint: curing agent: fine = 4:1:9-10, paint dosage is 0.22 ~ 0.25 kg/m2, with a scraper blade coating; Construction standards: surface smooth, no scar, no sand, no obvious sand holes;
    第五:刮自流平色漆腻子两遍:配比自流平色漆:固化剂:石英粉=4:1:5-6 油漆用量0.15~0.20kg/m2,用刮刀刮涂;施工标准:要求不透底、无浮砂,表面无砂眼;
    Fifth: scrape self-leveling paint putty twice: ratio of self-leveling paint: curing agent: quartz powder = 4:1:5-6 paint dosage is 0.15 ~ 0.20 kg/m2, with a scraper blade coating; Requirements: the construction standard is not gone, no floating sand, surface without sand holes;
    第六:腻子层干后,打磨吸尘,清洁干净地面; 施工标准:无粉尘、无颗粒、无刮刀痕迹; 施工注意事项:只能用手动打磨机打磨,采用60-80 目的砂纸片;
    Sixth: putty layer after dry, grinding dust, clean the ground; Construction standards: no dust, no particles, no traces scraper; Construction note: can only use manual polishing machine polishing, the 60-80 purpose sandpaper;
    第七:镘涂自流平面漆:油漆用量0.80~1.1kg/m2 配比自流平色漆: 固化剂=4:1,用镘刀镘开,镘刀齿宽、齿深以2-3mm 为宜,镘刀与地面成45°角左右,用消泡滚筒消泡;施工标准:表面颜色一致,基本无气泡、无镘刀及消泡滚筒痕迹、无浮色发花、无旋涡缩孔现象,2m 靠尺平整度不大于2mm。
    Seven: steamed bread with their flat paint: paint dosage ratio of 0.80 ~ 1.1 kg/m2 self-leveling paint: curing agent = 4:1, with a trowel trowel, trowel tooth width and tooth depth with 2-3 mm advisable, trowel around 45 ° Angle with the ground, with a foam roller defoaming; Construction standards: surface consistent color, basic no bubbles, no trowel and foam roller trace, no floating color hair flower, no vortex phenomenon of shrinkage cavity, 2 m on foot flatness is not more than 2 mm.

     济南自流平 http://www.jndmzp.com/

鲁公网安备 37148202000237号