• 联系人:小马师傅
  • 电话:18560041881
  • 地址:济南市北园大街86号
新闻中心当前位置:首页-新闻中心
    来源:http://www.jndmzp.com/   时间:
    空中找平的留意事项及流程
    来源:http://www.jndmzp.com   时间:2018-12-7 16:31:14
    空中找平的留意事项及流程
    Notices and Procedures for Air Leveling
    房屋空中找平分楼层面和地根底面,找平要留意控制好平整度和标高,用仪器打点,多做几个水准点,再把接触面松懈的杂物凿打清算洁净。找平层不是很厚可以间接用水泥砂浆找平压光;假如是在原砼面上找平较厚要先植钢筋头,再铺钢筋网片,然后浇筑砼组织与原砼开裂分层。面层是完成面的还要用机器磨平光面,当前面层就不容易起砂。
    In leveling the floor and the ground floor in the air, attention should be paid to controlling the evenness and elevation, dotting with instruments, making several more leveling points, and then chiseling out the loose debris in the contact surface. If the leveling layer is not very thick, it can be leveled and calendered indirectly with cement mortar. If the leveling layer is thicker on the original concrete surface, the steel head should be planted first, then the steel mesh should be laid, and then the concrete structure and the original concrete cracking layer should be poured. The surface layer is a complete surface and needs to be smoothed by a machine. The current surface layer is not easy to sand.
    水泥砂浆空中找平施工工艺、流程及验收规范
    Construction Technology, Process and Acceptance Specification of Cement Mortar Air Leveling
    1、空中找平的标准顺序:
    1. Standard order of air leveling:
    基层处置→找标高、弹线→洒水潮湿→抹灰饼和标筋→搅拌砂浆→刷水泥浆结合层→铺水泥砂浆面层→木抹子搓平→铁抹子压一遍→二遍压光→三遍压光→养护
    Base treatment elevation finding, elastic line sprinkling moisture plastering cake and reinforcement mixing mortar brushing cement mortar bonding layer paving cement mortar surface layer rubbing wood plaster pressing iron plaster once twice polishing three times polishing maintenance
    房屋空中找平
    House leveling in the air
    2、将基层上的灰尘扫掉,用钢丝刷和錾子刷净、剔掉灰浆皮和灰渣层,用10%的火碱水溶液刷掉基层上的油污,并用清水及时将碱液冲净。
    2. Clean up the dust on the base, brush with wire brush and chips, remove the mortar skin and ash slag layer, wash off the oil stain on the base with 10% caustic soda solution, and rinse the alkali solution with clear water in time.
    3、依据墙上的+1000mm程度线,往下量测出面层标高,并弹在墙上。
    3. According to the + 1000mm level line on the wall, the surface elevation is measured downwards and bounced on the wall.

    济南地面找平

    4、依据房间内周围墙上弹的面层标程度线,定面层抹灰厚度(不应小于20mm),然后拉程度线开端抹灰饼(5cm*5cm),横竖间距爲1.5—2.0米,灰饼上立体即爲空中面层标高。假如房间比拟大,还须抹标筋。铺抹灰饼和标筋的砂浆资料配合比均与抹空中的砂浆相反。

    4. According to the level line of the surface marking on the wall around the room, the plastering thickness of the fixed layer should not be less than 20 mm, and then the plastering cake at the beginning of the drawing level line (5cm*5cm), the horizontal and vertical spacing is 1.5-2.0 meters, and the three-dimensional surface marking on the ash cake is the height of the air. If the room is comparatively large, it needs to be marked with tendons. The mix ratios of mortar materials with plastering cake and standard reinforcement are opposite to those with plastering air.
    5、搅拌砂浆,用搅拌机停止搅拌,颜色要一样。
    5. Mix mortar, stop mixing with mixer, the color should be the same.
    7、铺设水泥砂浆前,涂刷水泥浆一层(随刷随铺面层砂浆)。
    7. Before laying cement mortar, brush one layer of cement mortar (with brush with pavement mortar).
    7、在涂刷完水泥砂浆后,铺水泥砂浆,并在灰饼之间将砂浆铺平均。
    7. After the cement mortar is painted, the cement mortar is laid, and the mortar is evenly laid between the ash cakes.
    8、木抹子刮平后,用铁抹子压一遍,直到出浆爲止。面层砂浆初凝后,用铁抹子压二遍,外表压平压光。在水泥砂浆终凝行进行第三遍压光,必需在终凝前完成。 并用2米靠尺反省其平整度。
    8. After scraping the wooden plaster, press it with the iron plaster until pulping. After the initial setting of the surface mortar, press it twice with an iron plaster and smooth the surface. The third calendering of cement mortar during final setting must be completed before final setting. The smoothness is reflected with a 2-meter ruler.
    9、竣工后24小时(空中压光),铺锯末或其他资料掩盖洒水养护,坚持潮湿,养护工夫不少于7天,抗压强度达5Mpa时才干上人。
    9. 24 hours after completion (air calendering), paving sawdust or other materials to cover up the sprinkler maintenance, adhere to wet, maintenance time is not less than 7 days, compressive strength of up to 5 Mpa to dry.
    综上所述有小马识途地面找平提供,想了解多济南地面找平知识,欢迎关注我们的网站:http://www.jndmzp.com谢谢支持!
    In summary, all the above-mentioned pony ground leveling services, want to know more about Jinan ground leveling knowledge, welcome to pay attention to our website: http://www.jndmzp.com Thank you for your support!

鲁公网安备 37148202000237号